 |
Parts
Covered Under
Extended Warranty |
 |
 |
| Mechanical
Breakdown |
| |
|
| » Engine:
|
cylinder head, head gasket, oil
pump and drive, crankshaft, flywheel, and ring
gear, timing gears, belts and chains, camshaft,
cam follower, valves (excluding burnt and pitted
valves), vale gear, pistons, connecting rod, gudgeonpin,
distributor drive, inlet and exhaust manifolds,
bore \ liner, turbo, intercooler units where factory
fitted. |
 |
| » Clutch: |
clutch pressure plate, clutch disc, release
bearing, master and save cylinder, clutch cable
(failure due to worn or burnt clutches are not
covered). |
|
| » Transmission: |
internal gear, shafts, synchromesh rings and
hub, bushes, selector forks, drive chains, gear
level and bushes (failure due to worn or burn
out clutches and bands are not covered). |
|
| » Transfer case: |
all internal parts |
|
| » Coolant: |
radiator, water pump, thermostat, engine oil
cooler (failure due to external damage or corrosion
is not covered). |
|
| » Steering system: |
rack and pinion, steering box, column, shaft
bearings, couplings, power steering pump, pressure
pipes, reservoir. |
|
| » Propshaft: |
shaft, universal joints, center bearings |
|
| » Final drive: |
crown wheel and pinion, different gears, hub,
drive flange. |
|
| » Front wheel drive: |
drive shaft and coupling, constant velocity
joints, hub, drive flange. |
|
| » Fuel system: |
carburettor, chock unit, fuel pump, injector
pump, E C U, cold start valve, pressure damper,
auxiliary valve, overrun cut off valve, deceleration
valve, tank sender unit. |
|
| » Break system: |
servo, master cylinder, wheel cylinder, diesel
vacuum pump, calipers, discs (excluding brake
pads / liners), drums, handbrake lever and ratchet. |
|
| » Suspension: |
* shock absorbers (excluding
fluid leakage), bush \ mechanical failures,
control arms, upper and lower wishbones, springs.
|
|
| » Casings: |
should failure of any if the components covered
result in damage to the casing, then they will
also be covered and will constitute part of the
maximum claim liability. |
|
|
| Emission |
| |
| Diesel
Engine |
| » Exhaust System: |
EGR valve, EGR actuation system. |
|
| » Intake System: |
air intake throttle, air mass flow meter, air
temperature sensor, oil separator and PVC valve. |
|
| » Fuel System: |
assembly fuel injection pump, assembly injector. |
|
| » Cold Start System: |
glow plug, fast idle control device. |
|
| » Evaporative Emission Control: |
canister purge valve, fuel tank cap and relief
valve. |
|
» Engine Management System:
|
water temperature sensor, crank angle sensor,
vehicle speed sensor. |
|
| |
| Petrol
Engine |
| » Exhaust System: |
secondary air pump, EGR
valve, EGR actuation system. |
|
| » Intake System: |
assemble throttle body (which includes map sensor,
throttle position sensor and idle speed control
valve), air mass flow meter, air temperature sensor,
cam angle sensor. |
|
| » Fuel System: |
fuel rail, fuel pressure, injectors. |
|
| » Ignition System: |
distributor, ignition coil. |
|
| » Evaporative Emission Control: |
canister purge valve, fuel tank
cap and relief valve. |
|
» Engine Management System:
|
water temperature sensor, crank angle sensor,
vehicle speed sensor, distributor, ignition coil. |
|
|
| Electrical |
| » Electrical System: |
starter motor and solenoid, alternator,
distributor, coil, wiper and washer motor, window
motors, fan motors, switches and instruments.
(Exclusions: batteries, light bulbs / units, wiper
blades / rubbers, distributor caps and leads.) |
|
| » Air Conditioning: |
compressor, condenser, evaporator, and clutch
magnet. (Exclusions: hoses and pipes, drive belts
and routine recharging of refrigerant.) |
|
|
::-
NOISE / HUMMING / BUZZING SOUNDS ARE EXCLUDED (E.G.
BEARINGS, RACK AND PINION) |
| ::- * SHOCK
ABSORBERS ARE COVERED UPTO 35,000 KM. |
|